Owner guide · Toyota of Fox Lake · Fox Lake, IL
Toyota Tundra Maintenance Schedule
What Toyota's 2027 Tundra and Tundra i-FORCE MAX Maintenance Guides list at each mileage, side by side, from the 5,000-mile visit to differential oil, spark plugs and coolant, read November 10, 2026. If your Tundra is serviced with us on U.S. 12 in Fox Lake, this is what Toyota lists for each visit.
What is the Toyota Tundra maintenance schedule?
Toyota's 2027 Tundra and Tundra i-FORCE MAX Maintenance Guides recommend scheduled maintenance every 5,000 miles or six months, whichever comes first. Every visit includes a tire rotation and fluid, brake, wiper and floor mat checks; the engine oil and filter are replaced every 10,000 miles; differential oil, chassis and steering inspections and a propeller shaft bolt torque are added every 15,000 miles; and the cabin and engine air filters are replaced every 30,000 miles. Spark plugs are replaced every 40,000 miles, and engine coolant is first replaced at 100,000 miles. The i-FORCE MAX adds an HEV battery cooling intake filter that is cleaned every 20,000 miles.
2027 Tundra maintenance schedule, mile by mile
| When | Tundra (gas) | Tundra i-FORCE MAX |
|---|---|---|
| Every 5,000 miles / 6 months | Rotate tires; inspect all fluid levels; inspect brake linings/drums and brake pads/discs (visual); inspect wiper blades; check installation of the driver's floor mat | Same, plus inspect the HEV battery cooling intake filter |
| Every 10,000 miles / 12 months | Everything at 5,000 miles, plus replace the engine oil and oil filter | Everything at 5,000 miles, plus replace the engine oil and oil filter |
| Every 15,000 miles / 18 months | Adds inspections of the ball joints and dust covers, brake lines and hoses, drive shaft boots (if applicable), exhaust pipes and mountings, front differential oil (if applicable), radiator/condenser/intercooler (if applicable), rear differential oil, steering gear, and steering linkage and boots; torque the propeller shaft bolts | Same inspections and propeller shaft bolt torque as gas |
| Every 20,000 miles | Not listed | Clean the HEV battery cooling intake filter (20,000, 40,000, 60,000 miles and on) |
| Every 30,000 miles / 36 months | Adds replacing the cabin air filter and engine air filter; inspecting the automatic transmission fluid and its cooler hoses and connections, the fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses, the fuel tank cap gasket and the transfer case oil (if applicable); and inspecting brake thickness and disc runout | Same as gas |
| Every 40,000 miles | Replace the spark plugs (40,000, 80,000 and 120,000 miles) | Replace the spark plugs (40,000, 80,000 and 120,000 miles) |
| 60,000 miles, then every 15,000 miles | Inspect the drive belts (60,000, 75,000, 90,000 miles and on) | Inspect the drive belts (60,000, 75,000, 90,000 miles and on) |
| 100,000 miles / 120 months | First engine/intercooler coolant replacement (if applicable); then every 50,000 miles / 60 months | First engine/intercooler coolant replacement (if applicable); then every 50,000 miles / 60 months |
| 120,000 miles | Inspect the vacuum pump for the brake booster; a chart note says to replace the vacuum pump vane and vane caps with new ones and never reuse them | Not listed |
| 150,000 miles / 180 months | Not listed | First inverter/intercooler coolant replacement (if applicable); then every 50,000 miles / 60 months |
From the maintenance charts (5,000 to 150,000 miles) of Toyota's 2027 Tundra Maintenance Guide and 2027 Tundra i-FORCE MAX Maintenance Guide, read November 10, 2026. Each later visit also includes the items of the shorter intervals that fall on it. In Hawaii only, the charts also list adding EFI tank additive at every 5,000-mile visit. The all-fluid-levels check includes looking for leaks from sealed transmissions, transfer cases and differentials, the power steering fluid (if equipped), the brake fluid level and condition, and the engine and inverter (if equipped) coolant level, condition and freezing point.
Miles or months: which comes first
Toyota recommends scheduled maintenance every 5,000 miles or six months, whichever comes first. The guides give two examples: if you drive 5,000 miles in less than six months, get maintenance at 5,000 miles; if at six months you have driven less than 5,000 miles, get maintenance at six months.
For low-mileage drivers, the guides suggest marking your calendar to get maintenance every six months. They also say to check the engine oil level once a month, and to see the "Maintenance" section of your owner's manual for the ongoing fluid checks and visual inspections between visits. For the oil viscosity rating, the guides point to the owner's manual.
The i-FORCE MAX guide opens with safety precautions for its high-voltage hybrid system: do not touch or try to remove or replace any high-voltage (orange-colored) wiring and connectors, and do not touch the service plug (orange service plug or green interlock plug). For the HEV battery cooling intake filter cleaning procedure, it refers to the "Maintenance and Care" section of the owner's manual.
Special operating conditions
The charts add these services only if most of your driving is done under the conditions shown. If you only occasionally drive this way, the guides say the extra services are not necessary.
Dirt or dusty roads
Both guides, every 5,000 miles or 6 months: replace the engine oil and filter; inspect the engine air filter (replace it every 30,000 miles), ball joints and dust covers, drive shaft boots, and steering linkage and boots; and torque the nuts and bolts on the chassis and body and the propeller shaft bolts. Replace the transfer case oil every 30,000 miles.
Towing, car-top carrier or heavy loading
Both guides: torque the chassis and body nuts and bolts and the propeller shaft bolts every 5,000 miles; replace the front differential oil every 15,000 miles and the rear differential oil and transfer case oil every 30,000 miles; and inspect the automatic transmission fluid at 30,000, 90,000 and 150,000 miles and replace it at 60,000 and 120,000 miles. Not all vehicles are designed for towing; see your owner's manual.
Roads with road salt
Torque the propeller shaft bolts every 5,000 miles.
Short trips below freezing
Repeated trips of less than five miles in temperatures below freezing (32°F): replace the engine oil and filter every 5,000 miles or 6 months, even when the maintenance reminder does not appear.
From the Special Operating Conditions charts in Toyota's 2027 Tundra and Tundra i-FORCE MAX Maintenance Guides, read November 10, 2026.
Daily checks after off-road driving
On top of the mileage chart, both guides list items to check daily when you take the Tundra off-road through deep sand, mud or water:
- Ball joints and dust covers
- Brake lines and hoses
- Brake linings/drums and brake pads/discs
- Differential oil
- Drive shaft boots
- Engine air filter
- Nuts and bolts on chassis and body
- Propeller shaft bolts
- Steering linkage and boots
- Transfer case oil
- Transmission fluid
The gas guide marks the transfer case check for 4WD models; the i-FORCE MAX guide lists the front and rear differential oil separately. From the "Off-Road Daily Maintenance" pages of the 2027 Tundra and Tundra i-FORCE MAX Maintenance Guides.
Records, providers and your warranty
The guides say maintaining your vehicle according to their recommendations is required to keep your warranty coverage intact, and to keep detailed records: the date of service, the mileage and a description of the work. Toyota will not deny a warranty claim solely because you do not have records, but damage or failure caused by lack of proper maintenance is not covered.
Maintenance may be done by you or by any automotive service provider you choose, and Toyota will not deny a warranty claim solely because a provider other than a Toyota dealership did the work. A dealer may recommend more frequent intervals or more services than the chart lists; the guides say those additional services are not required to maintain warranty coverage, and to ask your dealer to explain any recommended maintenance not in the chart.
This page covers Toyota's 2027 Tundra and Tundra i-FORCE MAX Maintenance Guides (both version 8/31/26). For an earlier model year, use the guide for that year; your own guide and owner's manual are the final word.
Toyota of Fox Lake service hours
| Days | Hours |
|---|---|
| Mon-Thu | 7 a.m.-7 p.m. |
| Fri | 7 a.m.-6 p.m. |
| Sat | 7 a.m.-3 p.m. |
| Sun | closed |
From Toyota of Fox Lake's website, November 10, 2026. Holiday hours can differ.
Toyota Tundra maintenance FAQ
How often does a Toyota Tundra need maintenance?
Toyota's 2027 Tundra and Tundra i-FORCE MAX Maintenance Guides both recommend scheduled maintenance every 5,000 miles or six months, whichever comes first. If you drive 5,000 miles in less than six months, go at 5,000 miles; if you have driven less than 5,000 miles at six months, go at six months.
How often should a Tundra get an oil change?
Both 2027 guides list replacing the engine oil and oil filter every 10,000 miles or 12 months. A chart note says to replace both even when the maintenance reminder does not appear, after 12 months have passed or when driven over 10,000 miles since the last oil change. If the truck is mainly driven on dirt or dusty roads, or on repeated trips of less than five miles in temperatures below freezing, the guides say to replace the oil and filter every 5,000 miles or 6 months.
When does a Tundra need new spark plugs?
Both 2027 guides list replacing the spark plugs at 40,000, 80,000 and 120,000 miles. The guides note that spark plug maintenance is required under the terms of the Emission Control Warranty.
Is the Tundra i-FORCE MAX maintenance schedule different?
Mostly not: the oil, tire rotation, filter, brake, differential and propeller shaft intervals match. The i-FORCE MAX guide adds the HEV battery cooling intake filter (inspected at the 5,000-mile visits and cleaned every 20,000 miles) and the first inverter/intercooler coolant replacement (if applicable) at 150,000 miles. The gas guide lists a vacuum pump inspection for the brake booster at 120,000 miles; the i-FORCE MAX guide does not list it.
How often should Tundra differential oil be changed?
Under normal driving, the charts list inspecting the front differential oil and rear differential oil every 15,000 miles. If most of your driving is towing a trailer, using a car-top carrier or heavy vehicle loading, the charts list replacing the front differential oil every 15,000 miles and the rear differential oil and transfer case oil every 30,000 miles.
When should Tundra coolant be changed?
Both guides list the first engine/intercooler coolant replacement (if applicable) at 100,000 miles/120 months, then every 50,000 miles/60 months. The i-FORCE MAX guide also lists the first inverter/intercooler coolant replacement (if applicable) at 150,000 miles/180 months, then every 50,000 miles/60 months.
Do I have to service my Tundra at a dealer to keep the warranty?
No. The guides say maintenance may be performed by you or by any automotive service provider you choose, and Toyota will not deny a warranty claim solely because you used a provider other than a Toyota dealership. Damage or failure caused by improper maintenance is not covered. Toyota also says to keep detailed records of each service.
Can Toyota of Fox Lake do my Tundra's scheduled maintenance?
Yes. Our service team in Fox Lake can perform the services in Toyota's maintenance charts for your Tundra or Tundra i-FORCE MAX's mileage. See the service hours above or schedule online.
Tundra due for service?
Bring it to Toyota of Fox Lake, 75 S US-12 in Fox Lake. Our service team can perform the maintenance Toyota lists for your Tundra's mileage.
Sources
Maintenance intervals, special operating conditions, off-road checks and warranty notes are from Toyota's 2027 Tundra and Tundra i-FORCE MAX Maintenance Guides (T-MMS-27Tundra, T-MMS-27TundraHV), read November 10, 2026. Your own guide and owner's manual are the final word for your vehicle. Address and hours are from Toyota of Fox Lake's own website. Photo is illustrative.
- 2027 Tundra Maintenance Guide (T-MMS-27Tundra, version 8/31/26): maintaining your warranty, using the maintenance charts, off-road daily maintenance, maintenance charts, explanation of maintenance items, Toyota, read November 10, 2026
- 2027 Tundra i-FORCE MAX Maintenance Guide (T-MMS-27TundraHV, version 8/31/26): safety precautions, maintaining your warranty, using the maintenance charts, off-road daily maintenance, maintenance charts, explanation of maintenance items, Toyota, read November 10, 2026
- Address and service hours, Toyota of Fox Lake, November 10, 2026
